P0402 2001 Toyota Camry Code - Exhaust Gas Recirculation Flow Excessive Detected
Quick Answer
Early Exhaust Gas Recirculation (EGR) systems component s include and EGR Valve, and Engine Control Μodule (ECΜ) Controlled Vacuum Switch Valve or EGR Solenoid and an EGR Vacuum Μodulator. Common causes include EGR volume control valve stuck open, Faulty EGR volume control valve, EGR solenoid valve harness is open or shorted. Severity is Moderate - service should be scheduled soon. The vehicle may still be drivable for short trips if it runs normally, but avoid hard driving and repair it soon.
- What it means
- P0402 2001 Toyota Camry indicates Exhaust Gas Recirculation Flow Excessive Detected.
- Common causes
- Common causes include EGR volume control valve stuck open, Faulty EGR volume control valve, EGR solenoid valve harness is open or shorted.
- Severity
- Moderate - service should be scheduled soon.
- Can I drive?
- The vehicle may still be drivable for short trips if it runs normally, but avoid hard driving and repair it soon.
Code P0402 2001 Toyota Camry Description
The EGR system on recently built vehicles uses a step motor to control the flow rate of EGR from exhaust manifold. This motor has four winding phases. It operates according to the output pulse signal of the ECΜ. Two windings are turned ON and OFF in sequence. Each time an ON pulse is issued, the valve opens or closes, changing the flow rate. When no change in the flow rate is needed, the ECΜ does not issue the pulse signal. Α certain voltage signal is issued so that the valve remains at that particular opening.
What are the Possible Causes of the DTC P0402 2001 Toyota Camry?
- EGR volume control valve stuck open
- Faulty EGR volume control valve
- EGR solenoid valve harness is open or shorted
- EGR solenoid valve circuit poor electrical connection
- Faulty EGR temperature sensor and circuit
- Manifold absolute pressure sensor
- ECM
How to Fix the DTC P0402 2001 Toyota Camry?
Review the 'Possible Causes' above and visually examine the corresponding wiring harness and connectors. Check for damaged components and inspect connector pins for signs of being broken, bent, pushed out, or corroded.
What is the Cost to Diagnose the Code?
Labor: 1.0
To diagnose the P0402 2001 Toyota Camry code, it typically requires 1.0 hour of labor. Rates vary by location, vehicle, and shop. Many shops charge between $80–$150 per hour; dealerships and metro areas may be higher, independents may be lower.
Need more information about the P0402 2001 Toyota Camry code?
Need more information on how to fix the P0402 2001 Toyota Camry code? Get Access to Factory Service Manuals
Need Help with the Code?
Get the P0402 2001 Toyota Camry code diagnosed by a professional: Find a repair shop in your area
Frequently Asked Questions about P0402 2001 Toyota Camry Code
1. What are the common symptoms of OBDII code P0402 in a 2001 Toyota Camry?
The common symptoms include rough idling, engine hesitation, decreased fuel efficiency, and the illumination of the check engine light.
2. What are the possible causes of OBDII code P0402 in a 2001 Toyota Camry?
The code P0402 in a 2001 Toyota Camry is usually caused by a faulty exhaust gas recirculation (EGR) valve, a clogged EGR passage, or a malfunctioning EGR position sensor.
3. How can I diagnose the OBDII code P0402 in my 2001 Toyota Camry?
You can diagnose the code P0402 by using an OBDII scanner to read the code and then inspecting the EGR valve, the EGR passages, and the EGR position sensor for any issues.
4. What are some repair tips for addressing OBDII code P0402 in a 2001 Toyota Camry?
Some repair tips include cleaning or replacing the EGR valve, clearing any clogs in the EGR passages, checking the EGR position sensor for proper operation, and ensuring all connections are secure.
5. Can I continue driving my 2001 Toyota Camry with OBDII code P0402?
It is not recommended to continue driving your vehicle with code P0402 as it can lead to further engine damage and reduced performance. It's best to address the issue promptly.
6. How much does it typically cost to repair OBDII code P0402 in a 2001 Toyota Camry?
The cost of repairing code P0402 can vary depending on the exact cause of the issue. On average, expect to pay between $150 to $500 for parts and labor.
7. Are there any preventive measures to avoid OBDII code P0402 in a 2001 Toyota Camry?
Regular maintenance, such as cleaning the EGR system components and using high-quality fuel, can help prevent issues that trigger code P0402 in your Toyota Camry.
8. Can a DIY enthusiast fix OBDII code P0402 in a 2001 Toyota Camry?
While some may attempt to fix code P0402 themselves, it is recommended to have a professional mechanic diagnose and repair the issue to ensure it is resolved correctly.
9. Will resetting the check engine light fix OBDII code P0402 in a 2001 Toyota Camry?
Simply resetting the check engine light will not fix the underlying issue causing code P0402. It's essential to address the root cause of the problem to prevent it from recurring.
10. How long does it take to repair OBDII code P0402 in a 2001 Toyota Camry?
The repair time for code P0402 can vary depending on the extent of the issue and the availability of parts. In general, the repair can take anywhere from 1 to 3 hours.
Discuss the causes and fixes for P0402 2001 Toyota Camry OBDII Code
Code P0402 2001 Toyota Camry comments
No comments found for this page.
Fix Your Car Smarter
Try the New AutoCodes App!
Get complete OBDII diagnostics, repair solutions, and cost estimates, plus AI chat support on demand.
